水泥自上料攪拌車現在無論是在工地建筑還是道路維修都有廣泛的應用，那么你知道攪拌車的空調濾清器使用要注意什么事項嗎？下面小編來為您講解一番。
Cement self loading mixer trucks are now widely used both in construction sites and road maintenance. Do you know what precautions should be taken when using air conditioning filters on mixer trucks? The editor will explain it to you.
夏天和冬天都會使用到空調，一般在這兩個季節到來之前，就需要對空調進行清理、清潔?？照{濾清器在使用過程中應定期清潔或更換，不然堵塞的濾清器會阻止并減少空氣進入蒸發箱。
Air conditioners are used in both summer and winter, and generally need to be cleaned before these two seasons arrive. Air conditioning filters should be regularly cleaned or replaced during use, otherwise clogged filters will prevent and reduce air from entering the evaporation tank.
因為水泥自上料攪拌車在使用中，若空氣濾清器過臟，會使進入汽缸內的空氣量減少，造成攪拌車的動力性能下降，速度加不上去。另外，空氣濾清器的質量應當可靠，若過濾不清，細微灰塵進入汽缸，將使活塞與缸筒之間的磨損加劇，從而降低發動機整體的使用壽命，這點是十分重要的。
If the air filter of the cement self loading mixer truck is too dirty during use, the amount of air entering the cylinder will be reduced, resulting in a decrease in the dynamic performance of the mixer truck and inability to increase its speed. In addition, the quality of the air filter should be reliable. If the filter is not clear and fine dust enters the cylinder, it will aggravate the wear between the piston and the cylinder barrel, thereby reducing the overall service life of the engine. This is very important.
空調雖然開的很大，但依然感覺不涼，有的車輛車內還伴有異味，對于沒有空調濾清器的空調車輛，當感覺出風口風量減少或開空調后車內有異味時，請到修理廠清洗蒸發箱，清潔后，會感覺車內空氣新鮮，涼度增加，相對也提高了攪拌車駕駛的舒適性。攪拌車的空氣濾清器一般需要在1.5萬公里更換一次，5000公里清潔一次。
Although the air conditioner is heavily turned on, it still feels not cool. Some vehicles also have a peculiar smell inside. For air-conditioned vehicles without air conditioning filters, when you feel that the air volume at the air outlet decreases or there is a peculiar smell inside the vehicle after the air conditioner is turned on, please go to the repair shop to clean the evaporation tank. After cleaning, you will feel that the air in the vehicle is fresh and the cooling degree increases, which relatively improves the driving comfort of the mixer truck. The air filter of a mixing truck generally needs to be replaced every 15000 kilometers and cleaned every 5000 kilometers.
合格的空氣濾清器可以長時間使用而無需保養。吸入空氣在與燃油混合之前，要先經過空氣濾清器，濾去灰塵、碳、部分水蒸氣及其他雜物后再進入氣缸。從理論上講，一單位體積的燃油燃燒時，大約需要一萬單位體積的清潔空氣。空氣濾清器的正常維護的更換周期為4.8萬千米，每2.4萬千米進行一次常規檢查。
Qualified air filters can be used for a long time without maintenance. Before mixing the inhaled air with fuel, it must first pass through the air filter to remove dust, carbon, some water vapor, and other debris before entering the cylinder. In theory, when a unit volume of fuel is burned, about 10000 units of clean air are required. The normal maintenance and replacement cycle of the air filter is 48000 kilometers, and a routine inspection is conducted every 24000 kilometers.
大氣中常見的三種雜質有灰塵、殘渣和碳粒。工地、風沙地區灰塵濃度較高，空氣濾清器的更換頻率要高一些；高速公路和車輛密集區域，車輛排放物多，空氣中碳含量較高。在檢查空氣濾清器的時候，要仔細查看褶皺內部深處。有時候外面看似干凈，內部已經非常臟了，這種情況下空氣濾清器的過濾能力減弱，建議及時更換。
The three common impurities in the atmosphere are dust, residue, and carbon particles. The dust concentration in construction sites and windy sand areas is high, and the replacement frequency of air filters should be higher; Highways and densely populated areas have high vehicle emissions and high carbon content in the air. When inspecting the air filter, carefully examine the depth of the wrinkles inside. Sometimes the outside looks clean, but the inside is already very dirty. In this case, the filtering ability of the air filter decreases. It is recommended to replace it in a timely manner.
That's all about the precautions for using the air conditioning filter on the mixer truck. If you have any doubts or use needs about this, please come to our website http://www.top2010.cn Leave a message for consultation!
上一篇：自上料水泥攪拌車氣剎和油剎的不同之處
下一篇：降低自動攪拌車的故障率要注意什么？
