保養機體的清潔，清除機體上的污物和障礙物，檢查各潤滑處的油料及電路和控制設備，并按要求加注潤滑油。每班工作前，在攪拌筒內加水空轉1--到2min，同時檢查離合器和制動裝置工作的可靠性。自上料水泥攪拌車運轉過程中，應隨時檢聽電動機，減速器，傳動齒輪的噪聲是否正常，溫升是否過高，每班工作結束后，應認真清洗自上料水泥攪拌車。
Maintain the engine body clean, remove the dirt and obstacles on the engine body, check the oil, circuit and control equipment of each lubricating place, and add lubricating oil as required. Before each shift, add water into the mixing drum and idle for 1-2 minutes, and check the reliability of the clutch and brake device at the same time. During the operation of concrete mixer, check whether the noise of motor, reducer and transmission gear is normal and whether the temperature rise is too high. After the end of each shift, the concrete mixer shall be cleaned carefully.
在對自上料水泥攪拌車進行清洗時應注意以下事項:
Attention should be paid to the following matters when cleaning the concrete mixer:
定期進行保養規程所規定項目的維護、保養作業，如清洗、潤滑、加油等。
Regularly carry out the maintenance and maintenance of the items specified in the maintenance regulations, such as cleaning, lubrication, oiling, etc.

自上料水泥攪拌車開動前要先檢查各控制器是否良好，停工后用水和石子倒入攪拌筒內10~15分鐘進行清洗，再將水和石子清出。操作人員如須進入攪拌筒內清洗時，除切斷電源和卸下熔斷器外，并須鎖好開關箱。禁止用大錘敲打的方法清除積存在自上料水泥攪拌車筒內的混凝土，只能用鑿子清除。在嚴寒季節，工作完畢后應用水清洗攪拌機滾筒并將水泵、水箱、水管內積水放凈，以免水泵、水箱、水管等凍壞。
Before starting the concrete mixer, check whether the controllers are in good condition. After shutdown, pour water and stones into the mixing drum for 10 ~ 15 minutes for cleaning, and then clear the water and stones. If the operator needs to enter the mixing drum for cleaning, in addition to cutting off the power supply and removing the fuse, the switch box must be locked. It is forbidden to remove the concrete accumulated in the concrete mixer barrel by using a sledge hammer, but only with a chisel. In the severe cold season, after the work is finished, the mixer drum shall be cleaned with water, and the accumulated water in the water pump, water tank and water pipe shall be drained to avoid freezing damage to the water pump, water tank and water pipe.
感謝您的閱讀，此文的文章來源：中科自上料水泥攪拌車更多的內容和問題請點擊：http://www.top2010.cn我們會繼續努力的為您提供服務，感謝您的支持！
Thank you for reading. This article is from Zhongke concrete mixer. For more information and questions, please click: http://www.top2010.cn We will continue to work hard to provide services for you, thank you for your support!

上一篇：小型攪拌車如何從日常工作中預防事故的產生
下一篇：小型攪拌機的操作應該注意哪些內容？