在保證混凝土質量的同時，攪拌車的安全駕駛和保養護理也同樣值得重視，那么攪拌車有哪些使用攻略，能幫助我們更好地使用和保養呢？
At the same time of ensuring the quality of concrete, the safe driving and maintenance of the mixer are also worth paying attention to. What are the use strategies of the mixer that can help us better use and maintain it?
1、攪拌車液壓傳動系統液壓油的壓力、油量、油質、油溫應達到規定要求，無滲漏現象。
1. The pressure, quantity, quality and temperature of the hydraulic oil in the hydraulic transmission system of the mixer truck shall meet the specified requirements without leakage.
2、攪拌運輸中，裝載混凝土量不能超過允許裝載質量。
2. During mixing and transportation, the amount of concrete loaded shall not exceed the allowable loading quality.
3、攪拌車在露天停放時，裝料前應先將攪拌筒反轉，使筒內的積水和雜物排出。裝料前，好先向筒內加少量水，使進料流暢，防止粘料。
3. When the mixer truck is parked in the open air, the mixing drum should be reversed before loading to drain the water and debris in the drum. Before loading, add a small amount of water into the cylinder to make the feeding smooth and prevent sticking.
4、攪拌車行駛中，接長的卸料槽必須翻轉后固定在卸槽上，再轉至與車身垂直部位，用銷軸與機架固定，防止由于不固定而引起擺動打傷行人或影響車輛運行.
4. During the driving of the mixer truck, the extended discharge chute must be turned over and fixed on the discharge chute, and then turned to the vertical position with the vehicle body, and fixed with the frame with a pin shaft, so as to prevent the pedestrian from being injured or the vehicle operation from being affected by the swing caused by the unfixed
5、攪拌車通過橋、洞、庫等設施時，應注意通過高度及寬度，以免發生碰撞事故。特別需要注意的是現在的四軸罐車的長度很長，在通過橋洞高度接近極，長長的車身是下圓弧路面上的一道弦，能通過的高度會減低.
5. When the mixer truck passes through bridges, holes, warehouses and other facilities, attention should be paid to the passing height and width to avoid collision accidents. It should be noted that the length of the current four axle tank car is very long. When the height of passing through the bridge opening is close to the limit, the long body is a string on the lower arc Road, and the height that can pass will be reduced
6、攪拌裝置連續運轉時間不超過8h。
6. The continuous operation time of the mixing device shall not exceed 8h.
7、攪拌車運送混凝土的時間不得超過攪拌站規定的時間，以免影響混凝土質量。
7. The time of transporting concrete by the mixer truck shall not exceed the time specified by the mixing plant, so as not to affect the quality of concrete.
8、運送混凝土途中，攪拌筒不得停轉、以防混凝土產生初凝乃離析現象.
8. During the transportation of concrete, the mixing drum shall not be stopped to prevent the initial setting and segregation of concrete
9、攪拌筒由正轉變為反轉時，必須先將操縱手柄放至中間位置，待攪拌筒停轉后，再將操縱手柄放至反轉位置。
9. When the mixing drum changes from positive to reverse, the control handle must be put to the middle position first, and then put the control handle to the reverse position after the mixing drum stops rotating.
10、
自動攪拌車的水箱的水量要經常保持裝滿，以防急用。冬季停車時，要將水箱和供水系統的水放干凈。
10. The water tank of the automatic mixer should always be kept full to prevent emergency use. When parking in winter, drain the water tank and water supply system.
The above is all about the problems and precautions introduced to you today. I hope it can help you. If you want to know more, you can contact us by phone or follow our website http://www.top2010.cn , our staff will contact you in time.
上一篇：水泥自上料攪拌車有時會出現幾種故障
下一篇：水泥攪拌車如何檢查搖臂總成及發動機預熱
