1．起動混凝土自動攪拌車之前，應把攪拌筒操作手柄放在“停止”位置。
1. Before starting the automatic concrete feeding mixer, put the operating handle of the mixing drum in the "stop" position.
2．混凝土自動攪拌車起動發動機后，應使攪拌筒在低速下轉動10分鐘左右，使液壓油溫升到20℃以上后方可工作。
2. After starting the engine of the automatic concrete feeding mixer, the mixing drum should be rotated at a low speed for about 10 minutes to make the hydraulic oil temperature rise to more than 20 ℃.
3．混凝土自動攪拌車在露天停放時，裝料前應將攪拌筒反轉，將積水和雜物排出，以保證混凝土的質量。
3. When the concrete automatic feeding mixer is parked in the open air, the mixing drum should be reversed before loading to discharge the water and debris, so as to ensure the quality of concrete.
4．混凝土自動攪拌車在運輸混凝土時，要保證滑斗放置牢固，防止因松動造成擺動，在行進中打傷行人或影響其它車輛正常運行。
4. When transporting concrete, the automatic concrete feeding mixer should ensure that the sliding bucket is firmly placed to prevent swing caused by looseness, hurting pedestrians or affecting the normal operation of other vehicles.
5.混凝土自動攪拌車裝運攪拌好的混凝土時，攪拌筒轉速為2-10轉/分，在運輸過程中，平坦路面上攪拌筒轉速保證在2-3轉/分，行駛在側傾坡度大于50的路面，或左右晃動較大的路面時，應停止攪拌旋轉，待路況好轉后再恢復攪拌旋轉。
5. When transporting the mixed concrete, the rotation speed of the mixing drum is 2-10 rpm. During transportation, the rotation speed of the mixing drum on the flat road should be 2-3 rpm. When driving on the road with a side slope greater than 50 or the road with large left and right shaking, the mixing rotation should be stopped, and the mixing rotation should be resumed after the road condition improves.
6.混凝土自動攪拌車運送混凝土的時間不能超過攪拌站規定的時間。運送混凝土途中，攪拌筒不得長時間停轉，以防混凝土產生離析現象。司機應時常觀察混凝土情況，發現異常及時通報調度室，申請做出處理。
6. The time of transporting concrete by automatic concrete feeding mixer shall not exceed the time specified by mixing station. During the transportation of concrete, the mixing drum shall not stop for a long time to prevent concrete segregation. The driver's cab shall be informed of the abnormal situation from time to time, and the application shall be handled in time.
7.混凝土自動攪拌車車內裝有混凝土時，在現場停滯時間不得超過1小時，如超時應立即要求現場負責人給予及時處理。
7. When the concrete is loaded in the automatic concrete feeding mixer, the dead time on site shall not exceed 1 hour. If it exceeds the time limit, the person in charge of the site shall be required to deal with it in time.
8.混凝土自動攪拌車運送混凝土塌落度不得低于8cm。從混凝土入罐到排出，氣溫高時不得超過2小時必須排出，陰雨天氣溫度低時，不得超過2.5小時。
8. The slump of concrete transported by automatic concrete feeding mixer shall not be less than 8cm. From the time of concrete entering the tank to discharging, it must be discharged within 2 hours when the temperature is high, and within 2.5 hours when the temperature is low in rainy weather.
9.混凝土自動攪拌車在排出混凝土之前，應使攪拌筒在10-12轉/分的轉速下轉動1分鐘，再進行排料。
9. Before discharging the concrete, the automatic concrete feeding mixer should make the mixing drum rotate at the speed of 10-12 rpm for 1 minute before discharging.
10.混凝土自動攪拌車出料完畢，應立即用隨車的軟管放水將進料口、出料斗及出料溜槽等部位沖洗干凈，排去粘結在車身各處的污物及殘留混凝土，再向攪拌筒內注水150-200L的清水，在返回途中要讓攪拌筒慢速轉動，以清洗內壁，避免殘余料渣附在筒壁和攪拌葉上，并在再一次裝料前將這些水放掉。
10. After the discharge of the automatic concrete feeding mixer, the feeding port, discharge hopper, discharge chute and other parts shall be cleaned immediately with the hose attached to the truck, and the dirt and residual concrete bonded to the body shall be removed. Then, 150-200l clean water shall be injected into the mixing drum. On the way back, the mixing drum shall rotate slowly to clean the inner wall, so as to avoid the residual slag adhering to the wall and mixing Put the water on the leaves and let it off before loading again.
11.混凝土自動攪拌車運送混凝土時，發動機轉速在1000-1400轉/分范圍內工作，以使發動機有扭距，在運送混凝土過程中，車速不得超過40km/h，以保行車安全。
11. When the concrete is transported by the automatic concrete feeding mixer, the engine speed shall be in the range of 1000-1400 rpm to make the engine have the maximum torque. In the process of transporting concrete, the speed shall not exceed 40km / h to ensure the driving safety.
12.混凝土自動攪拌車工作完畢，應把攪拌筒內部和車身清洗干凈，不能使剩余的混凝土留在筒內。
12. After the automatic concrete feeding mixer is completed, the inside and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.
13.混凝土自動攪拌車在水泵工作時，禁止空轉，連續使用時不要超過15分鐘。
13. When the water pump is working, the concrete automatic feeding mixer is not allowed to run idly, and the continuous use should not exceed 15 minutes.
14.混凝土自動攪拌車水箱的水量要經常保持裝滿，以備急用，冬季停機后，應將水箱、水泵、水管、攪拌筒內的水放凈，并停放在朝陽、不積水的地方，以免凍壞機械。
14. The water volume of the water tank of the automatic concrete feeding mixer should always be kept full for emergency use. After shutdown in winter, the water in the water tank, water pump, water pipe and mixing drum should be drained, and the water should be parked in the Chaoyang place without ponding, so as to avoid freezing the machinery.
15.混凝土自動攪拌車在冬季應及時安裝保溫套，并使用防凍液對自動攪拌車加以保護，根據天氣變化更換燃油標號，確保機械的正常使用。
15. The concrete automatic feeding mixer should be installed with insulation sleeve in winter, and antifreeze should be used to protect the automatic feeding mixer, and the fuel label should be changed according to the weather change to ensure the normal use of the machinery.
16.在檢查、修理混凝土自動攪拌車液壓傳動部分時，應使發動機和液壓泵在沒有壓力的情況下進行。
16. When checking and repairing the hydraulic transmission part of automatic concrete feeding mixer, the engine and hydraulic pump should be operated without pressure.
17.在調整混凝土自動攪拌車各部間隙、行程、壓力時，應由專職安全員檢查同意；更換機件時，必須由部長或主管經理簽字，否則出現問題后追究有關人員責任。
17. When adjusting the clearance, travel and pressure of each part of the automatic concrete feeding mixer, it shall be checked and agreed by the full-time safety officer; when replacing the parts, it must be signed by the minister or the manager in charge, otherwise the relevant personnel will be investigated for responsibility after the problems occur.
The above Zhongke Jufeng concrete mixer is the content to share with you. For more wonderful content, please click http://www.top2010.cn Enter our website, or search our keywords, we will have more wonderful content to share with you!
上一篇：攪拌車空調裝置的保養使用特點介紹
下一篇：中科攪拌車購買后需要磨合嗎？
